Product ID:SPRAYDET RS
MSDS Date:04/04/1996
FSC:6850
NIIN:00N072154
MSDS Number: CBXQS

C&H CHEMICAL INC

222 STARKEY ST
ST PAUL, MN 55107
US

Emergency Phone: 800-228-5635

Info Phone: 612-227-4343

Cage: 0ZAU9

C AND H ENTERPRISES INC

SAINT PAUL, MN 55107 US

Telephone: 651-227-2485

Cage: 0ZAU9

SODIUM HYDROXIDE (CERCLA)

CAS: 1310-73-2

RTECS: WB4900000

Fraction By Weight: <50%

OSHA PEL 2 MG/M3

ACGIH TLV: 2 MG/M3, C

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ADDED TOO RAPIDLY; OR IF ADDED TO HOT OR COLD

RTECS: 9999999ZZ

SPATTERING &/OR BOILING WHICH MAY CAUSE AN IMMED

RTECS: 9999999ZZ

WHEN MAKING LARGE BATCHES OF CLEANER SOLUTIONS.

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

CLOTHING BE WORN WHEN MIXING LARGE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: THIS PRODUCT IS A CORROSIVE
MATERIAL. IT IS DESTRUCTIVE TO TISSUES CONTACTED AND CAN CAUSE
SEVERE BURNS. EYES: CAUSES BURNS. SKIN: CAUSES SEVERE BURNS IF NOT
RINSED OFF IMMEDIATELY. INHALATION: INHALATION OF DUST OR MISTS
CAUSES IRRITATION OF THE RESPIRATORY TRACT. INGESTION: IF
SWALLOWED, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CAUSES SEVERE BURNS OF MOUTH, THROAT
AND STOMACH. THIS PRODUCT CONTAINS AN AMINE WHICH MAY REACT WITH
NITRITES IN ACIDIC CONDITIONS TO FORM A NITROSAMINE. SOME
NITROSAMINES HAVE BEEN SHOWN T O BE CARCINOGENIC.
Medical Cond Aggravated by Exposure:UNKNOWN.

First Aid:EYES: IMMED FLUSH EYES W/PLENTY OF COOL RUNNING WATER. REMOVE
CONTACT LENSES IF APPLICABLE & CONTINUE RINSING FOR AT LEAST 15 MIN
WHILE HOLDING EYELIDS APART. CNTCT MD. SKIN: IMMED FLUSH W/PLENTY
OF C OOL RUNNING WATER FOR AT LEAST 15 MIN. REMOVE CONTAMD CLTHG &
WASH BEFORE REUSE. CNTCT MD IF IRRIT PERSISTS. INHAL: REMOVE TO
FRESH AIR. SEEK MED ATTN IF BRTHG DFCLTY OCCURS. INGEST: RINSE
(SUPDAT)

Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE PROTECTIVE CLOTHING TO AVOID SKIN CONTACT WITH
PRODUCT. PRODUCT DISSOLVES IN WATER.
Unusual Fire/Explosion Hazard:NONE (NON-COMBUSTIBLE SOLID).

Spill Release Procedures:USE CAUTION. FLUSH SMALL SPILLS TO SEWER
W/PLENTY OF WATER. LARGE SPILLS: SHOVEL UP AS MUCH AS POSSIBLE &
CONTAIN FOR REUSE. REMAINING TRACES CAN BE NEUTRALIZED W/DILUTE
ACID FLUSHED W/WATER FOLLOWED W/A LIBERAL COVERING OF SODIUM
BICARBONATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING. KEEP
CONTAINER CLOSED WHEN NOT IN USE FOR SAFETY AND TO PREVENT CAKING.
Other Precautions:WHEN MAKING SOLNS IN SPRAY WASH MACHINE PLACE
DETERGENT ON DRY FLOOR OF WASH CABINET OR PLATE ON TURNTABLE. CLOSE
DOOR & RUN SPRAY PUMP W/WARM OR HOT WATER FOR 5 MIN. WHEN MAKING
SOLNS IN TANK, ADD CL EANER SLOWLY TO SURF OF WARM (SUPDAT)

Respiratory Protection:NIOSH APPROVED DUST MASK WHEN HANDLING DRY
PRODUCT.
Ventilation:USE WITH ADEQUATE VENTILATION TO AVOID BREATHING
CONCENTRATED DUST, MISTS OR SPRAYS.
Protective Gloves:RUBBER TYPE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (ING 5)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . PROT
CLTHG AS NEEDED. IT IS RECOMMENDED THAT COMPLETE RUBBER (ING 6)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: MOUTH W/WATER THEN DRINK 1 TO 2 GLASSES OF MILK/WATER.
DO NOT INDUCE VOMIT. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON.
IMMED CALL FOR MED ADVICE/ASSISTANCE. OTHER PRECS: (NOT HOT) W ATER
W/CONSTANT STIRRING. CONTINUE STIRRING FOR 5 MIN. IF CLEANER
BECOMES TOO CONCENTRATED IN ONE AREA, OR IF (ING 2)

Solubility in Water:COMPLETE
Appearance and Odor:TAN GRANULAR SOLID; CHARACTERISTIC ODOR.

Stability Indicator/Materials to Avoid:YES
ALUMINUM, ZINC, LEATHER, STRONG ACIDS AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SEE MIXING INSTRUCTIONS IN OTHER
PRECAUTIONS. AVOID MIXING WITH NITRATES; MAY FORM HAZARDOUS
NITROSAMINES.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN.

Waste Disposal Methods:REUSE SPILLED MATERIAL IF POSSIBLE. DISPOSE OF
WASTE IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS. CONSULT LOCAL AUTHORITIES FOR THE APPLICABLE RULES IN
YOUR AREA GOVERNING A LKALINE WASTES. CONTAINS SODIUM HYDROXIDE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.